1998-2001 Honda VFR800 INTERCEPTOR SERVICE MANUAL – PDF DOWNLOAD
DESCRIPTION:
1998-2001 Honda VFR800 INTERCEPTOR SERVICE MANUAL – PDF DOWNLOAD
HOW TO USE THIS MANUAL
- This service manual describes the service procedures for the VFR800FI. Follow the Maintenance Schedule (Section 3) recommendations to ensure that the vehicle is in peak operating condition and the emission levels are with in the standards set by the U.S. Environmental Protection Agency and California Air Resources Board. Performing the first scheduled maintenance is very important.
- It compensates for the initial wear that occurs during the break-in period. Sections 1 and 3 apply to the whole motorcycle. Section 2 illustrates procedures for removal/installation of components that may be required to perform service described in the following sections. Section 4 through 19 describe parts of the motorcycle, grouped according to location.
- Find the section you want on this page, then turn to the table of contents on the first page of the section. Most sections start with an assembly or system illusration, service information and troubleshooting for the section. The subsequent pages give detailed procedure. If you are not familiar with this motorcycle, read Technical Features in section 21. If you don’t know the source of the trouble, go to section 22 Troubleshooting.
- ALL IN FORMATION, ILLUSTRATIONS, DIREC TIONS AND SPECIFICATIONS INCLUDED IN THIS PUBLICATION ARE BASED ON THE LAT EST PRODUCT INFORMATION AVAILABLE AT THE TIME OF APPROVAL FOR PRIN TI NG . HONDA MOTOR CO., LTD.
- RESERVES THE RIGHT TO MAKE CHANGES AT ANY TIME WITHOUT NOTICE AND WITHOUT INCURRING ANY OBLIGATION WHATEVER. NO PART OF THIS PUBLICATION MAY BE REPRODUCED WITHOUT WRITTEN PERMISSION. THIS M AN UAL IS WRITTEN FOR PERSONS WHO HAVE ACQUIRED BASIC KNOWLEDGE OF M AINTE NANCE ON HONDA M OTORCYCLES, MOTOR SCOOTERS OR ATVS.
SERVICE RULES
1. Use genuine HONDA or HONDA-recommended parts and lubricants or their equivalents. Parts that don’t meet HONDA’s design specifications may cause damage to the motorcycle
. 2. Use the special tools designed for this product to avoid damage and incorrect assembly.
3. Use only metric tools when servicing the motorcycle. Metric bolts, nuts and screws are not interchangeable with English fasteners.
4. Install new gaskets, O-rings, cotter pins, and lock plates when reassembling.
5. When tightening bolts or nuts, begin with the larger diameter or inner bolt first. Then tighten to the specified torque diago – nally in incremental steps unless a particular sequence is specified.
6. Clean parts in cleaning solvent upon disassembly. Lubricate any sliding surfaces before reassembly. _/
7. After reassembly, check all parts for proper installation and operation.
8. Route all electrical wires as show on pages 1-24 through 1-43,Cable and Harness Routing.
TABLE OF CONTENTS:
1998-2001 Honda VFR800 INTERCEPTOR SERVICE MANUAL – PDF DOWNLOAD
Cover..................................... 1 Contents.................................. 2 1. General Information.................... 4 2. Frame/ Body Panels/ Exhaust............ 52 3. Maintenance............................ 76 4. Lube System............................107 5. Fuel System............................124 6. Cooling System.........................204 7. Engine Removal/ Installation...........223 8. Cylinder Head/ Valves..................237 9. Clutch.................................271 10. Gearshift.............................295 11. Crankcase/ Piston/ Cylinder...........307 12. Crankshaft/ transmission..............323 13. Front wheel/ suspension/ steering.....337 14. Rear Wheel/ Suspension................375 15. Hydraulic Brake.......................409 16. Battery/ Charging System..............453 17. Ignition System.......................467 18. Electrical Starter/ Starter Clutch....477 19. Lights/ Meters/ Switches..............495 20. Wiring Diagram........................558 21. Technical Features....................522 22. Troubleshooting.......................559 23. Index.................................563
VIDEO PREVIEW OF THE MANUAL:
IMAGES PREVIEW OF THE MANUAL:
PLEASE NOTE:
- This is the SAME exact manual used by your dealers to fix your vehicle.
- The same can be yours in the next 2-3 mins as you will be directed to the download page immediately after paying for the manual.
- Any queries / doubts regarding your purchase, please feel free to contact [email protected]
S.M