CLARK FORKLIFT SPM 628 CM 5/7 CP 7/10/12 SERVICE MANUAL

Description

CLARK FORKLIFT SPM 628 CM 57 CP 71012 SERVICE MANUAL – PDF DOWNLOAD

CLARK FORKLIFT SPM 628 CM 5/7 CP 7/10/12 SERVICE MANUAL:

Image Preview:

Description:

CLARK FORKLIFT SPM 628 CM 57 CP 71012 SERVICE MANUAL – PDF DOWNLOAD

• Do not operate this truck unless you have been trained 7 . Watch swing clearance when turning near walls racks, and authorized to do so. pillars or other obstacles. 2. Do not operate this truck until you have checked its condition. Give special attention to tires, battery, controls, lifting systems including switches, brakes, steering mechanism, guards and devices.
• 8 . Start, stop, change direction, travel and brake smoothly. Slow down for turns and on uneven or slippery surfaces thai could cause truck to slide or tip. Be aware that the truck behaves differently without a load than with a load. . Report the need for truck repairs to your supervisor promptly.
• Do not operate truck. Neglect may cause a minor repair to become a major service problem and cause the truck to become unsafe. 9 . Observe applicable traffic regulations yield right of way to pedestrians. Slow down and sound horn at all aisle intersections and where vision is obstructed.
• I. Do not exceed the rated capacity of the vehicle as marked on the nameplate. Do not lift with fork tips or one fork only, and be sure load is centered and forks are pushbed completely under load. 5. Do not handle unstable or loosely stacked loads.
• Use special care when handling long, high or wide load to avoid tipping, loss of load or striking bystanders. 10. Do not ride on truck unless equipped with rider platform. 11. Do not carry passengers. 12. Before you leave the truck, fully lower lifting mechanism, shut off power, remove key. 13. Do not leave truck unattended on ramp.

Table Of Contents:

CLARK FORKLIFT SPM 628 CM 57 CP 71012 SERVICE MANUAL – PDF DOWNLOAD

ARRIVAL INSPECTION
TABLE OF CONTENTS
SERVICE / MAINTENANCE HISTORY
PRE-OPERATION INSTRUCTIONS
SAFETY INFORMATION
TO ORDER PARTS
BATTERY DISCHARGE INDICATOR OPERATION
PREVENTIVE MAINTENANCE
BATTERY MAINTENANCE
BODY ASSEMBLY/LUBRICATION POINTS
P-SERIES STAK-MATE
P-SERIES CHARGER OPERATION
P-SERIES POWER PACK PARTS LIST
M-SERIES STAK-MATE
SYSTEM CONTROL
OPERATING INSTRUCTIONS
TROUBLE SHOOTING GUIDE
BATTERY CABLE CONNECTIONS
BATTERY CABLE CONNECTIONS
ELECTRONIC SPEED CONTROLLER WIRING DIAGRAM

Please Note:

• This is the SAME manual used by the dealers to troubleshoot any faults in your vehicle. This can be yours in 2 minutes after the payment is made.
• Contact us at [email protected] should you have any queries before your purchase or that you need any other service / repair / parts operators manual.

sk