Cummins ISC and ISL CM2150 Service Manual (4021569) – PDF DOWNLOAD

Description

Cummins ISC and ISL CM2150 Service Manual (4021569) – PDF DOWNLOAD

FILE DETAILS:

Cummins ISC and ISL CM2150 Service Manual (4021569) – PDF DOWNLOAD

Language : English
Pages :1661
Downloadable : Yes
File Type : PDF

DESCRIPTION:

Cummins ISC and ISL CM2150 Service Manual (4021569) – PDF DOWNLOAD

General Information
Cummins® Common Rail Fuel System

• The fuel system is a high-pressure common rail injection system. A fuel rail is used to store pressurized fuel for fuel injection. There are four components that provide or receive input to the electronic control module (ECM).
• The ECM powers the electric fuel lift pump (located behind the ECM) for approximately 30 seconds at keyon to prime the fuel system. The normally open fuel pump actuator receives a pulse width modulated (PWM) signal from the ECM to open or close in response to the signal from the fuel rail pressure sensor.
• The injectors have individual solenoids. The ECM powers each injector individually to provide fueling to each cylinder.

IMAGES PREVIEW OF THE MANUAL:

TABLE OF CONTENTS:

Cummins ISC and ISL CM2150 Service Manual (4021569) – PDF DOWNLOAD

ANSI American National Standards Institute
API American Petroleum Institute
ASTM American Society of Testing and Materials
BTU British Thermal Unit
BTDC Before Top Dead Center
°C Celsius
CO Carbon Monoxide
CCA Cold Cranking Amperes
CARB California Air Resources Board
C.I.B. Customer Interface Box
C.I.D. Cubic Inch Displacement
CNG Compressed Natural Gas
CPL Control Parts List
cSt Centistokes
DEF Diesel Exhaust Fluid
DOC Diesel Oxidation Catalyst
DPF Diesel Particulate Filter
ECM Engine Control Module
EFC Electronic Fuel Control
EGR Exhaust Gas Recirculation
EPA Environmental Protection Agency
°F Fahrenheit
13-2-22 QuickServe Online | (4021569) ISC and ISL CM2150 Service Manual
https://www.quickserve.cummins.com/qs2/portal/service/manual/en/4021569/ 2/3
ft-lb Foot-Pound Force
FMI Failure Mode Indentifier
GVW Gross Vehicle Weight
Hg Mercury
hp Horsepower
H2O Water
inHg Inches of Mercury
in H20 Inches of Water
ICM Ignition Control Module
IEC International Electrotechnical Commission
km/l Kilometers per Liter
kPa Kilopascal
LNG Liquid Natural Gas
LPG Liquified Petroleum Gas
LTA Low Temperature Aftercooling
MIL Malfunction Indicator Lamp
MPa Megapascal
mph Miles Per Hour
mpq Miles Per Quart
N•m Newton-meter
NOx Mono-Nitrogen Oxides
NG Natural Gas
O2 Oxygen
OBD On-Board Diagnostics
OEM Original Equipment Manufacturer
OSHA Occupational Safety and Health Administration
PID Parameter Identification Descriptions
ppm Parts Per Million
psi Pounds Per Square Inch
PTO Power Takeoff
REPTO Rear Power Take Off
RGT Rear Gear Train
rpm Revolutions Per Minute
13-2-22 QuickServe Online | (4021569) ISC and ISL CM2150 Service Manual
https://www.quickserve.cummins.com/qs2/portal/service/manual/en/4021569/ 3/3
SAE Society of Automotive Engineers
SCA Supplemental Coolant Additive
SCR Selective Catalytic Reduction
STC Step Timing Control
SID Subsystem Identification Descriptions
VDC Volts of Direct Current
VS Variable Speed
VSS Vehicle Speed Sensor

Contact us: [email protected]

S.M