Cat 3100 HEUI Diesel Truck Engine Service Shop Manual – PDF DOWNLOAD

Description

Cat 3100 HEUI Diesel Truck Engine Service Shop Manual – PDF DOWNLOAD

IMAGES PREVIEW OF THE MANUAL:

DESCRIPTION:

Cat 3100 HEUI Diesel Truck Engine Service Shop Manual – PDF DOWNLOAD

8WL1-Up
1WM1-Up
4ES1-Up
2CW1-Up
8HW1-Up
7LZ1-Up

Introduction :

The specifications given in this book are оп the basis of information availaЫe at the time the book was written. These specifications give the torques, operating pressures, measurements of new parts, adjustments and other items that will affect the service of the product. When the words “use again” are in the description, the specification given сап Ье used to determine if а part сап Ье used again.

• If the part is equal to or within the specification given, use the part again. When the word “permissiЬle” is in the description, the specification given is the “maximum or minimum” tolerance permitted before adjustment, repair and/or new parts are needed. А comparison сап Ье made between the measurements of а worn part and the specifications of а new part to find the amount of wear. А part that is worn сап Ье safe to use if an estimate of the remainder of its service life is good.
• If а short service life is expected, replace the part. NOTE: The specifications given for “use again” and “permissiЫe” are intended for guidance only and Caterpillar lnc. hereby expressly denies and excludes any representation, warranty or implied warranty of the reuse of any component. Reference: See 3100 HEUI Diesel Truck Engine, SENR6558, for Systems Operation, Testing and Adjusting.

Important Safety Information :

Most accidents involving product operation, maintenance and repair are caused Ьу failure to observe basic safety rules or precautions. An accident сап often Ье avoided Ьу recognizing potentially hazardous situations before an accident occurs. А person must Ье alert to potential hazards. This person should also have the necessary training, skills and tools to perform these functions properly.

• Improper operation, lubrication, maintenance or repair of this product сап Ье dangerous and could result in injury or death. Do not operate or perform апу lubrication, maintenance or repair оп this product, until you have read and understood the operation, lubrication, maintenance and repair information.
• Safety precautions and warnings are provided in this manual and оп the product. lf these hazard warnings are not heeded, bodily injury or death could occur to you or other persons. The hazards are identified Ьу the “Safety Alert Symbol” and followed Ьу а “Signal Word” such as “WARNING” as shown below.

TABLE OF CONTENTS:

Cat 3100 HEUI Diesel Truck Engine Service Shop Manual – PDF DOWNLOAD

Specifications
Air Compressor 34
Air lnlet And Exhaust System
Air lnlet Elbow 13
Ether Starting Aid 33
lnlet Air Heater 33
Camshaft 11
Cylinder Head 10
Exhaust Manifold 12
Turbocharger 12
Valve Cover 10
Valve Rocker Arms And Lifters 9
Valves 9
Basic Engine Components
Adapter Group (Engine То Transmission) 31
Connecting Rod 22
Connecting Rod And Main Bearing Journals 23
Crankshaft 21
Crankshaft Pulley Group 21
Crankshaft Seals 20
Cylinder Block 18
Cylinder Block Cover Group 20
Flywheel 26
Flywheel Housing 26
Flywheel Housing Ваге 28
Flywheel Housing Runout 28
Flywheel Runout 27
Front Gear Group 24
Front Housing 25
Front Housing Cover 25
Piston Cooling Jet 19
Pistons And Rings 22
Cooling System
Belt Tension Chart 16
Fan Drive 17
Water Pump 15
Water Pump Belt Тightener 16
Water Temperature Regulator 17
Electrical System
Alternator 32
Electric Starting Motor 32
Electronic Control Group (Wiring And Sensors) 30
lnlet Air Heater 33
Regulator 33
Wiring Group (Air lnlet Heater) 34
Engine Design 4
Fuel System
Fuel Heater And Water Separator 6
Fuel Lines Group 5
Fuel Filter Lines Group 5
Fuel Transfer Pump 8
High Pressure Oil Pump 8
Hydraulic Electronic Unit lnjector (HEUI) 6
3100 HEUI Diesel Truck Engine 3
Hydraulic Oil Lines 7
Hydraulic Pump Group 8
lnjection Actuation Pressure Control Valve 8
Lubrication System
Breather (Crankcase) 14
Engine Oil Pressure 15
Oil Cooler Bypass Valve 14
Oil Filter Base 14
Oil Pump 13

CAT 3100 HEUI DIESEL TRUCK ENGINE SERVICE SHOP MANUAL – PDF DOWNLOAD:

PLEASE NOTE:

• This is the SAME manual used by the dealers to troubleshoot any faults in your vehicle. This can be yours in 2 minutes after the payment is made.
• Contact us at [email protected] should you have any queries before your purchase or that you need any other service / repair / parts operators manual.

 S.V