Challenger Articulated Tractors RTS MT945E MT955E MT965E MT975E Workshop Service Manual

Description

Challenger Articulated Tractors RTS MT945E MT955E MT965E MT975E Workshop Service Manual – PDF DOWNLOAD

IMAGES PREVIEW OF THE MANUAL:

DESCRIPTION:

Challenger Articulated Tractors RTS MT945E MT955E MT965E MT975E Workshop Service Manual – PDF DOWNLOAD

Introduction :
This Repair Time Schedule gives the average time necessary for each repair procedure.
То calculate the average time for each repair, AGCO includes these conditions:
• one approved technician does the repair
• in typical work conditions
• with the correct tools
• оп а used ог correctly serviced machine
AGCO also includes the time to:
• find the cause of the fault
• get the correct tools and parts
• do а test before and after the repair
AGCO does not include time necessary to:
• go to and from the machine
• clean the machine
• remove and install any attached equipment

• The repair times аге shown in hours and parts of hours. Parts of hours аге in decimals. Use decimal times оп warranty claims.
• Repair times аге based оп the latest information available at the time of publication. AGCO reserves the right to publish revisions to these repair times as necessary. Revised repair times аге the result of changes in the design, method ог technique.

INDEX :

Challenger Articulated Tractors RTS MT945E MT955E MT965E MT975E Workshop Service Manual PDF DOWNLOAD

А
air conditioning and heating system
actuator 11-133
air conditioner 11-133
air conditioner group, basic 11-133
air conditioner group, deluxe 11-133
air conditioning cover 11-135
air filter 11-133
air intake filter 11-136
basic air and temperature controls 11-133
Ыower 11-133
control module 11-133
cover assemЬly-heating, ventilation, and air
conditioning 11-135
deluxe air and temperature controls 11-133
drain pan 11-133
duct seal 11-136
evaporator temperature sensor 11-133
expansion valve 11-133
filters, duct, and air vents 11-136
hose 11-136
HVAC gaskets 11-133
HVAC relay 11-133
HVAC temperature sensor 11-133
louver 11-136
lower air filter 11-136
lower air filter cover 11-136
water valve 11-133
wiring harness 11-133
attachments
counterweight group, front 18-167
counterweight group, front – 2016 18-167
counterweight group, front – non-CE 18-167
counterweight group, front-CE 18-167
counterweight group, front, 963 kilograms 18-167
front counterweights
flag pin 18-167
mounting bracket 18-167
weight spacer plate 18-167
slow moving vehicle warning group 18-170
tow саЫе 18-169
tow саЫе installation-special application 18-169
wheel counterweight 18-168
wheel counterweight arrangement’, 1816 kilo
18-168
wheel counterweight group
special application 18-168
wheel counterweight group, 1000 lb 18-168
wheel counterweight group, 454 KG 18-168
??
axle assemЫy, final drive 2-46
axle lube filter assemЫy 2-51
axle lube lines group 2-50
axle lubricant filter 2-51
axle shaft 2-46
bearing 2-46
carrier 2-46
filter and housing 2-51
Articulated Tractors RTS
57528501С
в
filter Ыосk 2-51
final drive axles 2-46
front axle assemЫy, high capacity 2-46
front axle assemЫy, high capacity differential 2-52
front axle drive shaft
U-joint 2-52
yoke 2-52
front axle lubrication line 2-50
front axle return line 2-50
lubrication lines 2-50
output shaft, front 2-52
planetary gear 2-46
pressure line 2-50
pressure switch 2-51
rear axle assemЫy, high capacity 2-46
rear axle drive shaft
adapter 2-53
axle input yoke 2-53
connector 2-53
elbow 2-53
Tee-fitting 2-53
rear axle lubrication line 2-50
rear axle return line 2-50
ring gear 2-46
seal 2-46
shaft group-front 2-53
shaft group-rear 2-53
shaft group, front 2-52
suction line 2-50
transmission return line 2-50
brake system
accumulator 6-82
accumulator hose 6-83
brake саЫе 6-82
brake charge return hose 6-83
brake charge supply hose 6-83
brake charge supply tube 6-83
brake control assemЫy 6-82
brake controls 6-82
brake filter assemЫy 6-78
brake group, hydraulic trailer brake, with drawbar
brake group, hydraulic trailer brakes-3 point hitch
brake line bracket 6-83
brake lines 6-83
brake lines group, non СЕ – service brake 6-80
brake oil filter 6-78
brake pin 6-82
brake return hose 6-83
brake rod 6-82
brake suction tube 6-83
brake supply tube 6-83
brake valve
coil 6-79
connector 6-79
elbow 6-79
quick coupler 6-79
lndex-1
lndex
с
саЬ
solenoid valve 6-79
brake valve assemЫy 6-80
brake valve repair kit 6-80
cartridge valve assemЬly 6-80
check valve 6-80
elbow 6-83
half flange 6-83
НТВ connector
НТВ return hose
НТВ suction tube
НТВ tube
hydraulic trailer brake valve
hydraulic trailer brake valve and lines
park brake bracket 6-83
park brake саЫе 6-83
park brake return hose 6-83
park brake supply hose 6-83
park brake valve assemЫy 6-79
park brake valve group 6-79
pilot brake hose
pressure switch, 240 PSI 6-80
reducer fitting 6-83
service brake hose 6-83
service brake tube – rear 6-83
service brake valve and lines 6-80
solenoid valve group 6-80
tee bulkhead fitting 6-83
tow override pilot hose 6-83
valve assemЫy 6-80
air tank 10-122
armrest 10-120
armrest adjustment lever 10-120
armrest Е СМ 10-120
armrest group, 4 valve, with hitch 10-120
armrest group, 4 valve, without hitch 10-120
armrest group, 5 valve, with hitch 10-120
armrest group, 5 valve, without hitch 10-120
armrest group, 6 valve, without hitch 10-120
armrest wire harness 10-120
bearing shaft 10-122
bracket 10-118
brake and clutch pedals 10-118
brake pedal 10-118
саЬ front visor group 10-114
саЬ group-CE 10-128
саЬ group-non СЕ 10-128
саЬ rear visor group 10-114
саЬ side visors group 10-114
саЫе pin 10-118
camera саЫе 10-120
cell phone holder 10-131
center console assemЫy 10-131
clutch pedal 10-118
coat hook 10-131
compartment assemЫy 10-131
compressor kit 10-122
console 10-120
console mounting bracket 10-122
control console 10-120
cover assemЫy – left hand b-post 10-131
decelerator control group
lndex-2
accelerator 10-116
arm 10-116
bracket 10-116
bushing 10-116
clip 10-116
decelerator pedal 10-116
link 10-116
position sensor 10-116
retaining ring 10-116
sensor retaining ring 10-116
door gas spring assemЫy 10-131
door glass 10-127
door group, left hand 10-128
door hinge 10-128
door striker 10-128
door striker guard 10-128
filter 10-126
fingertip switch 8-89
floor insulation 10-131
floormat 10-131
front window glass 10-127
front windshield 10-127
handle 10-128
headliner 10-126
hinge 10-126
holder net 10-131
housing 10-122
implement control group 8-89
implement valve armrest controls 8-89
insulation 10-126
knob kit 10-114
latch 10-126
left door 10-128
left hand cover 10-131
left hand door 10-127
left hand mirror 10-130
left hand rear саЬ panel assemЬly 10-131
left hand support 10-130
lid assemЫy 10-131
magnet 10-131
manual holder Ьох 10-122
mirror 10-130
mirror adjustment switch 10-130
mirror assemЫy 10-131
mirror assemЫy, left hand 10-130
mirror assemЫy, right hand 10-130
mirror group, electric 10-130
mirror group, electric-French 10-130
mirror group, manual 10-130
mirror mounting group-left hand 10-130
mirror mounting group-right hand 10-130
mirror wire harness 10-130
mirrors 10-130
monitor plug 10-131
plastic bushing 10-118
plate 10-118
plunger switch 10-118
plunger switch bracket 10-118
position arm bracket 10-118
position sensor 10-118
post cover 10-131
push button switch installation 10-115
rear window bar clamp 10-127
rear window glass 10-127
rear window hinge 10-127
Articulated Tractors RTS
57528501С
retaining ring 10-118
right hand b-post cover assemЫy 10-131
right hand glass 10-127
right hand mirror 10-130
right rear post plate 10-131
rocker switch 10-130
rod end 10-118
roof 10-126
seal 10-126
seat а i r spri ng kit 10-122
seat air tank service kit 10-122
seat back cushion 10-122
seat bearing kit 10-122
seat belt kit 10-122
seat bumpers kit 10-122
seat control kit 10-122
seat cover kit 10-122
seat cushion kit 10-122
seat fore and aft isolator shock kit 10-122
seat harness kit 10-122
seat knob kit 10-122
seat rocker switch 10-122
seat roller kit 10-122
seat service kit 10-122
seat shaft kit 10-122
seat shock suspension kit 10-122
seat slide kit 10-122
seat slide stop 10-122
seat spring kit 10-122
seat suspension kit 10-122
shift bush-button switch 10-115
shift control 10-115
shift handle 10-115
shift joystick 10-115
shock absorber kit 10-122
sleeve 10-118
slide mounting bracket 10-122
speaker bracket 10-126
sun shield 10-114
throttle lever 10-120
top rear window seal 10-127
torsion spring 10-118
training seat 10-122
training seat bracket 10-122
training seat hinge bracket 10-122
training seat hinge bushing 10-122
transmission control group, shift handle 10-115
transmission shifter control handle 10-115
trim group 10-131
trim group-2016 10-131
valve control lever 10-120
visors and windshield 10-114
window sun screen, left hand 10-114
windshield glass 10-127
wiper cover 10-126
wiper plate 10-126
wire cover 10-131
calculation of repair time 3
chassis
belly pan assemЫy-special application 12-145
cast aluminum step 12-146
center chassis step leg 12-146
deflector arrangement, fan Ьlast 12-145
DOC cover 12-139
door stop tube 12-146
Articulated Tractors RTS
57528501С
lndex
engine cover 12-139
engine cover and guard group 12-139
engine cover group 12-139
engine cover insulator 12-139
engine cover support
left tube 12-142
plate 12-142
right tube 12-142
step 12-142
support bracket 12-142
engine cover support group 12-142
engine fan group-guard 12-143
fan guard 12-143
fan guard group-engine fan 12-143
fan guard group, Ыast-MT800 12-143
fan guard, left 12-143
fan guard, right 12-143
fender channel – rear 12-146
fender group, front, left hand 12-137
fender group, front, right hand 12-137
fender group, rear, left hand 12-137
fender group, rear, right hand 12-137
fender support assemЫy 12-137
fenders 12-137
flexiЫe step extension 12-146
front fender channel mount 12-137
gas strut 12-139
grab handle 12-139
grille 12-139
grille assemЫy 12-139
guards 12-145
handrail group, inner 12-144
handrail group, outer 12-144
handrail tube mount 12-144
handrail, inner 12-144
handrail, outer 12-144
handrails 12-144
insulation 12-139
latch assemЫy 12-139
left hand fender shield assemЫy 12-137
left hand fender support 12-137
left hand front fender assemЫy 12-137
left hand front fender frame 12-137
left hand lamp shield 12-137
left hand rear fender assemЫy 12-137
left hand rear fender frame 12-137
mud guard assemЫy 12-145
platform – left 12-146
powertrain guards 12-145
prop rod 12-139
radiator grille 12-139
rear engine cover 12-139
rear fender channel mount – long 12-137
rear fender channel mount – medium 12-137
rear fender channel mount – short 12-137
rear fender handrail 12-137
row marker 12-139
rubber bumper 12-146
service cabinet group
door 12-138
frame 12-138
handle 12-138
hinge 12-138
latch 12-138
panel 12-138
lndex-3
lndex
special application guards 12-145
stamped steel step 12-146
step frame – rear 12-146
step handrail 12-146
step plate 12-146
step support 12-146
steps 12-146
top grille panel 12-139
compressed air system
D
air pressure service kit 7-86
air trailer brakes
quick connector 7-86
signal line 7-86
supply line 7-86
air trailer brakes coupler lines – single 7-86
air trailer brakes valve group 7-86
air trailer brakes with drawbar valve group 7-86
dual air trailer brake coupler assemЫy 7-86
decals
саЬ decal group – North America 13-148
саЬ decal group international 13-148
chassis decal installation – international 13-148
chassis decal installation – North America ” 13-148
decal group Challenger 13-148
decal group-2016 13-148
decal group-MT900E 13-148
decal group-MT955E 13-148
decal group-MT965E 13-148
decal group-MT975E 13-148
decal group, 3 point hitch, international 13-148
decal group, 3 point hitch, North America ” 13-148
decal installation-F USE 13-148
decal installation, electrical – international ” 13-148
decal installation, electrical – North America
13-148
decal installation, engine – international 13-148
electrical decal installation – international 13-148
electrical decal installation – North America 13-148
emЬlem assemЬly, Challenger 13-149
emЬlem mount assemЬly 13-149
engine decal installation – international 13-148
engine decal installation – North America 13-148
engine hood emЫem 13-149
high pressure tag, international 13-148
high pressure tag, North America 13-148
hydraulic decal installation 13-148
hydraulic decal installation – international 13-148
hydraulic decal installation – N orth America 13-148
warning plate installation, се 13-148
drive train system
case and parts group – planetary 5-77
charge pressure relief valve 5-66
charge pressure sensor 5-66
control group wire harness 5-66
cover group, transmission 5-69
drive group-dual axis 5-68
drive shaft U-joint 5-63
driveshaft, РТО rear 5-63
front case cover 5-77
front transmission case 5-70
housing assemЫy 5-68
hydraulic pump arrangement – transmission ” 8-95
lndex-4
hydraulic pump drive
bearing 5-68
gear 5-68
O-ring 5-68
shaft 5-68
thrust disc 5-68
hydraulic pump, triple 8-95
implement pump 8-95
input drive shaft
transmission to engine 5-64
U-joint 5-64
input shaft 5-74
input speed sensor 5-66
intermediate shaft 5-74
modulating valve 5-66
oil cooler bypass valve 5-66
output shaft 5-74
output speed sensor 5-66
planetary case
bearing cup 5-77
elbow 5-77
housing seal 5-77
lip seal 5-77
pressure filter 5-65
rear articulation drive shaft
driveshaft, РТО articulated 5-67
lubrication fitting 5-67
support 5-67
U-joint 5-67
rear drive shaft 5-63
rear transmission cover 5-70
reverse shaft 5-74
shaft group-input shaft 5-64
shaft group-rear 5-63, 5-67
sight gauge
elbow 5-73
fitting 5-73
hose 5-73
suction filter 5-65
suction screen filter 5-68
transfer output shaft 5-74
transmission 5-70
transmission breather 5-70
transmission case 5-77
transmission clutch
disc 5-71
dowel 5-71
plate 5-71
ring gear 5-71
seal 5-71
spring 5-71
transmission control group 5-66
transmission covers 5-69
transmission fill tube 5-70
transmission filter 5-65
transmission hydraulic pump 8-95
transmission lubrication relief valve 5-66
transmission shafts
bearing 5-74
friction disc 5-74
gear 5-74
O-ring 5-74
piston 5-74
retainer 5-74
seal 5-74
Articulated Tractors RTS
57528501С
spacer
spring
transfer gear group
transmission, СVТ, M L260
Е
5-74
5-74
5-74
5-65
electrical system
4 battery mounting group 9-103
antenna 9-109
antenna group 9-109
armrest group, 4 valve 9-112
armrest group, 5 valve 9-112
armrest group, 6 valve 9-112
armrest switch 9-112
backup alarm 9-108
backup alarm warning group 9-108
backup alarm warning group, 3 point hitch 9-108
backup alarm warning group, drawbar 9-108
backup alarm warning group, field installation
9-108
battery саЫе clamp kit 9-103
battery group 9-103
battery group, with disconnect 9-103
battery, maintenance free, wet 9-103
beacons 9-100
саЬ fuses 9-106
саЬ harness 9-104
саЬ positive саЫе 9-106
саЬ relays 9-106
саЬ wiring
negative саЫе 9-104
positive саЫе 9-104
switched power 9-104
unswitched power 9-104
саЬ work light 9-100
chassis work light 9-100
circuit breaker 9-104
control module 9-112
courtesy lamp 9-104
delay wiper switch 9-110
disconnect switch 9-103
electrical ballast 9-100
electrical group, sauer 9-112
engine cover work light 9-100
extension tube 9-101
extremity lights and signal lights 9-101
fuse Ыосk 9-106
heater cord 9-102
heater element 9-102
hood work light 9-100
light switch 9-104
lighting 9-100
lighting wire harness 9-104
negative battery саЫе 9-103
positive battery саЫе 9-103
power port 9-104
radio 9-109
radio kit, deluxe-field installation kit 9-109
radio kit, without antenna – field installation kit
9-109
radio, deluxe-field installation, xm 9-109
reflector 9-101
roof harness 9-104
roof module 9-104
Articulated Tractors RTS
57528501С
lndex
satellite antenna 9-109
satellite ready-field installation kit 9-109
signal lights, саЬ 9-100
signal lights, chassis 9-100
speaker and covers 10-113
speaker bracket 10-113
speakers 10-113
sump heater 9-102
trailer harness and switches 9-107
transmission heater group, 120 volt 9-102
transmission heater group, 240 volt 9-102
transmission oil heater 9-102
USB charger 9-104
windshield wiper 9-110
wiper arm 9-110
wiper Ыаdе 9-110
wiper group, basic 9-110
wiper group, deluxe 9-110
wiper kit, right hand 9-110
wiper motor 9-110
wiper switch 9-110
work light 9-100
engine, fuel, and exhaust system
accessory drive group 1-31
adapter 1-33
air conditioning compressor 1-31
air filter assemЬly 1-38
air filter cover 1-38
air filter element 1-38
air intake duct 1-38
air intake group 1-38
air tube 1-38
alternator 1-31
alternator pulley 1-31
arm 1-24
baffle 1-33
belt 1-31
belt tensioner 1-31
boost pressure sensor 1-21
bracket 1-30
breather tube 1-42
camshaft and valve mechanism-lash adjustment
1-24
camshaft speed sensor 1-21
сар 1-33
CCV filter 1-16
CCV intake hose group 1-16
charge air cooler hoses 1-35
charge oil cooler 1-32
closed crankcase ventilation 1-16
condenser 1-32
coolant heater 1-44
coolant hose 1-44
coolant piping 1-5
coolant pump air pipe 1-6
coolant pump and thermostat 1-6
coolant pump return pipe 1-6
coolant temperature sensor 1-21
cooler assemЫy 1-32, 1-33
cooler bracket 1-32
cooling package 1-33
cover 1-27
crankshaft hub 1-27
crankshaft pulley 1-27
crankshaft seal 1-20, 1-27
lndex-5
lndex
crankshaft speed sensor 1-21
cylinder Ыock-hydraulic lash adjustment 1-27
cylinder head 1-25
cylinder head gasket 1-25
cylinder liner ring 1-27
D E F connector 1-13
D E F filter 1-13
D E F modules, sensors, and valves 1-13
D E F tank 1-42
D E F tank assemЫy-DEF 1-42, 1-43
D E F tank group-MT900E 1-42
D E F valve 1-43
diesel exhaust fluid lines 1-43
diesel exhaust fluid tank group 1-42
dipstick 1-27
DOC 1-39
DOC clamp 1-39
DOC pipe 1-39
dosing module 1-13, 1-43
drain pipe 1-19
drain valve 1-33
drive pulley 1-31
ECU (engine control unit) 1-13
E G R actuator 1-12
EG R cooler 1-12
EG R return pipe 1-12
E G R valve 1-12
EG R water pipe 1-12
EGT sensor 1-39
electronic engine management 1-13, 1-21
engine fuel hose 1-36
engine wiring set 1-21
exhaust aftertreatment 1-13
exhaust clamp 1-39
exhaust connect tube 1-39
exhaust gas recirculation (EG R) 1-12
exhaust group 1-39
exhaust group – tier 4, final compliant 1-39
exhaust group-less regulated countries 1-39
exhaust manifold
seal 1-8
sleeve 1-8
exhaust outlet 1-39
exhaust pipe 1-39
exhaust stack 1-39
exhaust system 1-39
exhaust tee tube 1-39
exhaust temperature sensor 1-13
exhaust valve 1-25
expansion hose 1-33
expansion tank 1-33
fan 1-31
fan belt tensioner 1-30
fan shroud 1-33
filler neck 1-42
filter cover 1-13
filter hose 1-36
flywheel and housing 1-20
flywheel cover 1-20
flywheel input coupling 1-20
frame brace 1-32
fuel сар 1-42
fuel cooler 1-32
fuel cooler hose 1-36
fuel cooler tube 1-36
lndex-6
fuel filter 1-19
fuel injection system 1-17
fuel line 1-19
fuel lines and filters 1-19
fuel lines group 1-36
fuel lines group, fuel/water separator-less regulated
countries 1-36
fuel pipe 1-17
fuel pressure sensor 1-17, 1-21
fuel pressure valve 1-17
fuel tank hose 1-36
fuel temperature sensor 1-21
fuel tube 1-36
fuel water separator and fuel lines 1-36
fuel water separator filter 1-36
fuel water separator filter assemЫy 1-36
gasket and frame 1-24
gear housing front cover 1-27
high pressure injection pump 1-17
high pressure turbocharger
air pipe 1-9
air pipe heat shield 1-9
gasket 1-9
heat shield 1-9
high temperature bulk hose 1-33, 1-43
high temperature expansion hose 1-33
hood seal 1-33
injection pipe 1-17
inlet air heater 1-21
inlet air heater solenoid 1-21
inlet air temperature sensor 1-21
inlet hose 1-43
intake air preheater 1-7
intake manifold 1-7
intake manifold gasket 1-7
intake valve 1-25
internal temperature sensor 1-13
joint piece and gasket 1-25
left hand charge air cooler hose 1-35
lift еуе 1-27
liners 1-27
long Ыосk 1-27
long Ыосk engine 1-15, 1-24
long Ыосk engine service parts 1-15
low pressure turbocharger
air pipe 1-10
heat shield 1-1 О
lubrication oil pipe 1-10
O-ring 1-10
low pressure turbocharger and I CAC 1-10
magnetic proportional valve ( M PROP) 1-21
mass air flow ( MAF)sensor 1-21
nitrogen oxide sensor 1-41
NOx sensor 1-13
oil cooler 1-32
oil cooler and filter 1-14
oil dipstick 1-15
oil fill pipe 1-15
oil filter 1-14
oil pan
coupler 1-15
drain valve 1-15
plug 1-15
oil pan, pump and suction pipe 1-15
oil pipe 1-14
Articulated Tractors RTS
57528501С
F
oil pressure sensor 1-21
oil pump 1-15
oil pump suction pipe 1-27
oil sump 1-15, 1-27
oil sump gasket 1-15, 1-27
outlet hose 1-43
piston 1-27
pivot bracket 1-32
plug 1-27
prefilter 1-19
pressure control valve 1-21
pressure relief hose 1-36
pressure relief tube 1-36
primary ecu 1-21
push rod 1-27
push rods 1-24
radiator соге 1-32
rail pipe 1-17
right hand charge air cooler hose 1-35
rocker arm 1-24
rocker shaft 1-24
rocker valve cover
starting from engine serial number В67070
1-24
up to engine serial number В67050 1-24
roller 1-30
roller shaft 1-30
SCR parts assemЫy-16 8 L engine 1-41
SC R parts assemЫy-16 8 L engine selective
catalytic reduction 1-41
SCR system 1-41
secondary ecu 1-21
sensor 1-38, 1-42
starter 1-31
starter ring 1-20
suction pipe 1-15
supply module 1-13
support bracket 1-32
tee connector 1-33
temperature sensor 1-41
thermostat housing 1-6
throttle valve 1-21
turbo exhaust pipe 1-39
turbocharger inlet tube 1-35
urea valve 1-43
valve 1-33, 1-36
valve hose 1-36
valve rocker cover 1-27
vibration dampener 1-27
water jacket heater group, 120 volt 1-44
water jacket heater group, 240 volt 1-44
water pipe 1-5
water pump 1-6
water pump pulley 1-6
westgate actuator 1-21
wiring for actuators 1-21
wiring for injectors 1-21
wiring for intake air heaters 1-21
wiring for machine connector 1-21
frame and suspension
articulation bearing and seal 3-55
articulation compression spring 3-55
Articulated Tractors RTS
5 7528501С
н
lndex
саЬ mount 3-56
elbow fitting 3-54
engine mount 1-45
engine mounts and lift brackets 1-45
frame group, rear-fuel tank 3-54
fuel сар 3-54
fuel сар retainer 3-54
lift brackets 1-45
lynch pin 3-54
mount 1-45
needle valve 3-54
hydraulic system
4 bank valve group, 3/4 inch coupler 8-87
4 bank valve group, high flow, threaded port 8-87
5 bank valve group, 3/4 inch coupler 8-87
6 bank valve group, high flow, threaded 8-87
adjustment valve assemЫy 8-97
bearing cradle – piston pump – 63 се 8-97
case drain 8-90
case drain arrangement, flat face, 3 point 8-90
case drain arrangement, flat face, drawbar 8-90
case drain arrangement, flat face, hitch 8-90
case drain arrangement, pioneer, 3 point 8-90
case drain arrangement, pioneer, drawbar 8-90
case drain arrangement, pioneer, hitch 8-90
case drain bracket 8-90
case drain filter 8-90
case drain hoses 8-90
case drain, wide swinging drawbar 8-90
charge hose 8-98
check valve manifold 8-94
dust сар 8-91
elbow fitting 8-91
elbow fitting – 45 degree 8-97
elbow fitting – 90 degree 8-97
fingertip switch 8-89
gear pump 8-97
hose assemЫy 8-91
hydraulic filter group-implement 8-93
hydraulic filter pressure switch assemЬly 8-93
hydraulic fitting 8-91, 8-97
Hydraulic piston pump, 126СС 8-97
hydraulic piston pump, 85СС 8-97
hydraulic pump arrangement – transmission ” 8-95
hydraulic pump, triple 8-95
hydraulic tank 8-99
hydraulic tank group 8-99
implement control group 8-89
implement cooler lines
return hose 8-94
return tube 8-94
supply tube 8-94
implement coupler drain line 8-88
implement filter lines 8-94
implement filter return hose 8-98
implement filters
bracket 8-93
pressure switch 8-93
seal 8-93
valve 8-93
implement lines group, 4 hitch 8-92
implement lines group, 5 hitch 8-92
lndex-7
lndex
implement lines group, coupler drain 8-88
implement lines group, valve 8-92
implement lines group, valve drain 8-88
implement piston pump 8-97
implement pump 8-95
implement pump lines 8-98
implement valve 8-87
implement valve and coupler drain lines 8-88
implement valve armrest controls 8-89
implement valve drain line 8-88
implement valve line connector 8-92
implement valve lines 8-92
implement valve reference hose 8-98
O-ring seal – gear pump 8-97
O-ring seal – piston pump 8-97
piston control – piston pump – 63 се 8-97
piston pump 8-97
power beyond coupler 8-91
power beyond coupler and lines 8-91
priority supply hose 8-98
priority/steering return hose 8-98
pump group, 85СС 8-97
pump supply hose 8-98
rotary assemЫy – piston pump – 63 се 8-97
split flange 8-98
spring – piston pump – 63 се 8-97
steering pump case drain filter 8-90
swashplate – piston pump – 63 се 8-97
tank breather 8-99
tank drain plug 8-99
tank level sensor 8-99
tank sight gauge 8-99
tank temperature sensor 8-99
transmission cooler supply hose 8-96
transmission filter supply hose 8-96
transmission filter supply tube 8-96
transmission hydraulic pump 8-95
transmission lines 8-96
transmission lines group 8-96
transmission suction tube 8-96
transmission supply hose 8-96
tube assemЫy 8-91
valve dust cover 8-87
valve group 8-87
implement drive system
clutch group, power take-off 15-151
driveshaft, РТО rear 15-155
gearbox, rear РТО, type 3 15-155
housing assemЫy, front 15-151
housing assemЬly, rear 15-151
power take off assemЫy 15-155
powertrain 15-151
lndex-8
pto clutch
balance seal 15-151
brake plate 15-151
clutch plate 15-151
connector 15-151
elbow 15-151
end plate 15-151
friction disc 15-151
gear 15-151
M Dl :-C valve 15-151
O-ring
piston
relief valve
retaining ring
ring
ring spacer
shaft
spring
thrust disc
tube
yoke
yoke lip seal
yoke o-ring seal
РТО drive shaft
РТО drive shaft spacer plates
РТО gear
pto output shaft and gearbox
РТО seal
shaft cover
15-151
15-151
15-151
15-151
15-151
15-151
15-151
15-151
15-151
15-151
15-151
15-151
15-151
15-154
15-154
15-155
15-155
15-155
15-154
U-joint cover 15-154
implement lift system
3-point fender switch 16-162
3-point hitch control group 16-162
3-point hitch controls 16-162
3-point hitch group 16-158
3-point hitch lift cylinder lines 16-161
3-point hitch position sensor 16-162
3-point hydraulic lines 16-161
3-point linkage 16-158
3-point linkage accumulator 16-161
3-point linkage lift cylinder 16-159
3-point linkage lift cylinder lines 16-161
3-point linkage rockshaft 16-160
3-point position sensor arm 16-162
3-point position sensor rod 16-162
hitch level position sensor 16-162
hitch lines group – lift 16-161
hitch steering position sensor 16-162
hydraulic cylinder group, lift 16-159
lift arm 16-158
lift link group 16-158
link group, upper 16-158
linkage group, category 4, 3-point 16-158
linkage lift cylinder 16-159
quick coupler group 16-156
quick coupler group, category 4 16-157
quick coupler, 3-point, category 3 and 4 16-157
quick coupler, 3-point, category 5 16-156
quick hitch, category 5 16-156
rocker shaft 16-160
rockshaft 16-160
rockshaft bearings and seals 16-160
rockshaft group 16-160
rockshaft position sensor 16-162
sway limiter 16-158
top link 16-158
upper link 16-158
introduction 3
р
precision farming system
angle sensor jumper harness 17-164
articulation angle sensor 17-164
Auto-G uide саЬ harness 17-163
Articulated Tractors RTS
57528501С
Auto-Guide control switch
Auto-Guide jumper harness
Auto-Guide mounting bracket
Auto-Guide power switch
AutoGuide ready mounting group
data transfer unit
field accessories, telemetry
field kit-AutoGuide mounting
ground speed sensor
radar bracket
radar group, ground speed sensor
telemetry
telemetry antenna
telemetry arrangement
telemetry hardware kit
telemetry installation
telemetry module
See also radar
R
17-163
17-163
17-163
17-163
17-164
17-166
17-166
17-164
17-165
17-165
17-165
17-166
17-166
17-166
17-166
17-166
17-166
repair times allowance
calculation 3
s
steering system
cylinder hose – long 4-59
cylinder hose – short 4-59
cylinder pin 4-59
cylinder steering tube 4-59
electric steering, priority valve assemЬly 4-61
gas strut kit 4-57
hose support bracket 4-59
hydraulic cylinder group-steering 4-59
hydraulic lines-hydraulic steering cylinder 4-59
hydraulic steering group 4-61
hydraulic steering valve lines 4-62
hydraulic-electric steering group-steering group
4-61
long grease hose 4-59
short grease hose 4-59
steer valve tube 4-59
steering column 4-57
steering column assemЫy 4-57
steering control group 4-58
steering controls 4-58
steering cylinder 4-59
steering cylinder elbow 4-59
steering cylinder grease zerk 4-59
steering cylinder pin 4-59
steering cylinder spacer 4-59
steering cylinder yoke 4-59
steering hose 4-62
steering pilot 4-61
steering pilot hose 4-59
steering pilot-electric assemЫy 4-61
steering priority valve
connector 4-61
elbow 4-61
Tee-fitting 4-61
steering priority valve lines 4-62
steering shaft 4-58
steering tube 4-59, 4-62

CHALLENGER ARTICULATED TRACTORS RTS MT945E MT955E MT965E MT975E WORKSHOP SERVICE MANUAL:

PLEASE NOTE:

• This is the same manual used by the DEALERSHIPS to SERVICE your vehicle.
• The manual can be all yours – Once payment is complete, you will be taken to the download page from where you can download the manual. All in 2-5 minutes time!!
• Need any other service / repair / parts manual, please feel free to contact us at heydownloadss @gmail.com . We may surprise you with a nice offer

 S.V